|
|
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. ...more details
| Recall Reason |
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL |
| Recall Date |
OCT 05, 2009 |
| Model Affected |
AVALON |
| Potential Units Affected |
3800000 |
|
Recall Summary
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
|
|
Consequence
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
|
|
Remedy
TOYOTA WILL NOTIFY OWNERS OF AFFECTED VEHICLES TO REMOVE ANY DRIVER'S FLOOR MAT AND NOT REPLACE IT WITH ANY OTHER FLOOR MAT PENDING THE DEVELOPMENT OF MODEL-SPECIFIC REMEDIES. TOYOTA WILL MAIL A SECOND NOTIFICATION TO OWNERS OF AFFECTED VEHICLES NOTIFYING THEM OF THE FREE REMEDIES WHEN THEY ARE AVAILABLE. THE FIRST NOTICE WAS MAILED ON OCTOBER 30, 2009 AND TOYOTA WILL ADVISE NHTSA OF THE ESTIMATED DATE WHEN THE REMEDIES WILL BE AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
|
|
Notes
TOYOTA MOTOR CORPORATION
|
ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL. ...more details
| Recall Reason |
STEERING:COLUMN |
| Recall Date |
MAY 16, 2005 |
| Model Affected |
AVALON |
| Potential Units Affected |
4855 |
|
Recall Summary
ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL.
|
|
Consequence
LOSS OF CONTROL OF THE VEHICLE COULD RESULT IN A CRASH.
|
|
Remedy
DEALERS WILL INSPECT THE STEERING YOKE AND SHAFT WELD CONDITION, AND REPLACE THE STEERING COLUMN ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MAY 2, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
|
|
Notes
TOYOTA MOTOR NORTH AMERICA, INC. SSC 50F
|
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH. ...more details
| Recall Reason |
AIR BAGS |
| Recall Date |
APR 03, 2006 |
| Model Affected |
AVALON |
| Potential Units Affected |
133 |
|
Recall Summary
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
|
|
Consequence
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
|
|
Remedy
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
|
|
Notes
TOYOTA MOTOR NORTH AMERICA, INC. 60B 6LB
|
|