2004 Pontiac Montana Recalls
Read 2004 Pontiac Montana recall reports, with detailed explanations of the car defects, problems, and solutions from the manufacturer. There are 4 recalls listed for this Minivan/Van so don’t wait until the worst case scenario has happened! Be sure to check the latest 2004 Pontiac Montana recalls on a regular basis.
|
|
|
|
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER. ...more details
| Recall Reason |
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Recall Date |
MAR 12, 2007 |
| Model Affected |
MONTANA |
| Potential Units Affected |
742 |
|
Recall Summary
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
|
|
Consequence
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
|
|
Remedy
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
|
|
Notes
DELPHI
|
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED. ...more details
| Recall Reason |
LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Recall Date |
DEC 22, 2004 |
| Model Affected |
MONTANA |
| Potential Units Affected |
717302 |
|
Recall Summary
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
|
|
Consequence
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
|
|
Remedy
DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
|
|
Notes
GENERAL MOTORS CORP. 04110
|
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV). ...more details
| Recall Reason |
FUEL SYSTEM, GASOLINE:STORAGE |
| Recall Date |
AUG 08, 2007 |
| Model Affected |
MONTANA |
| Potential Units Affected |
20594 |
|
Recall Summary
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
|
|
Consequence
A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
|
|
Remedy
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
|
|
Notes
GENERAL MOTORS CORP. 06230
|
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, ¿CHILD RESTRAINT SYSTEMS.¿ THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AMENDMENTS TO THE STANDARD. ...more details
| Recall Reason |
EQUIPMENT:OTHER:LABELS |
| Recall Date |
APR 08, 2004 |
| Model Affected |
MONTANA |
| Potential Units Affected |
31301 |
|
Recall Summary
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, ¿CHILD RESTRAINT SYSTEMS.¿ THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AMENDMENTS TO THE STANDARD.
|
|
Consequence
|
|
Remedy
OWNERS WILL BE PROVIDED WITH REPLACEMENT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
|
|
Notes
GENERAL MOTORS CORP. 04022
|
There are currently no videos available for 2004 Pontiac Montana. Please try again later...
|