|
|
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL. ...more details
| Recall Reason |
AIR BAGS |
| Recall Date |
OCT 06, 2004 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
955344 |
|
Recall Summary
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
|
|
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
|
|
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
|
|
Notes
DAIMLERCHRYSLER CORPORATION D17
|
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE. ...more details
| Recall Reason |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Recall Date |
SEP 13, 2000 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
1163000 |
|
Recall Summary
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
|
|
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
|
|
Remedy
DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
|
|
Notes
DAIMLERCHRYSLER CORPORATION 895
|
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE. ...more details
| Recall Reason |
SEAT BELTS:REAR |
| Recall Date |
MAR 08, 2002 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
545311 |
|
Recall Summary
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
|
|
Consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
|
|
Remedy
DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
|
|
Notes
DAIMLERCHRYSLER CORPORATION B09
|
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS." ...more details
| Recall Reason |
VISIBILITY:GLASS, SIDE/REAR |
| Recall Date |
DEC 11, 2007 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
1657 |
|
Recall Summary
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
|
|
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
|
|
Remedy
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER¿S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
|
|
Notes
SAFELITE FULFILLMENT, INC.
|
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK. ...more details
| Recall Reason |
SERVICE BRAKES, HYDRAULIC |
| Recall Date |
MAR 13, 2006 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
7440 |
|
Recall Summary
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
|
|
Consequence
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
|
|
Remedy
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
|
|
Notes
BRAKE PARTS, INC.
|
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE. ...more details
| Recall Reason |
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Recall Date |
NOV 02, 2006 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
24358 |
|
Recall Summary
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
|
|
Consequence
FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
|
|
Remedy
AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
|
|
Notes
AIRTEX PRODUCTS
|
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ...more details
| Recall Reason |
EXTERIOR LIGHTING:HEADLIGHTS |
| Recall Date |
MAY 06, 1999 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
1635 |
|
Recall Summary
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
|
|
Consequence
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
|
|
Remedy
ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
|
|
Notes
DAIMLERCHRYSLER CORPORATION 829
|
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. ...more details
| Recall Reason |
EQUIPMENT |
| Recall Date |
SEP 26, 2003 |
| Model Affected |
VOYAGER |
| Potential Units Affected |
45870 |
|
Recall Summary
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.
|
|
Consequence
IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
|
|
Remedy
AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.
|
|
Notes
INTERCONTINENTAL AUTO PARTS
|
|